3717-1-02.4(C)(8) / Person in charge: duties - ensure employees are rapidly cooling TCS foods.
Critical The person in charge did not ensure that employees are using proper methods to rapidly cool TCS foods.
To prevent the growth of pathogens, the person in charge shall ensure that employees are using proper methods to rapidly cool TCS foods that are not held hot or are not for consumption within four hours.
3717-1-03.4(D) / Cooling - temperature and time control.
Critical TCS foods were not cooled using the proper time and temperature parameters. Observed chicken breast at 70F that were cooked 4 hours earlier.
To prevent the growth of pathogens, cooked TCS food shall be rapidly cooled: within two hours from 135°F to 70°F, and within a total of six hours from 135°F to 41°F or less; (2) TCS food shall be cooled within 4 hours to 41°F or less if prepared from ingredients at ambient temperature, such as reconstituted foods and canned tuna; (3) TCS food received in compliance with laws allowing a temperature above 41°F during shipment from the supplier, shall be cooled within 4 hours to 41°F or less; (4) Raw eggs shall be received at 45°F or less and immediately placed in refrigerated equipment that maintains an ambient air temperature of 45°F or less. Correct By: 29-Jul-2016
3717-1-03.4(F)(1) / Time/temperature controlled for safety food - hot and cold holding.
Critical Observed chicken breast and chunks being cooled for 4 hours at 70F. Person-in-charge moved the chicken to small batches to cool the food quicker.
To prevent the growth of pathogens, except during preparation, cooking, or cooling, or when time is used as a public health control, TCS food shall be held at 135°F or above (except that roasts cooked using time and temperature parameters in 3717-1-03.3 may be held at 130° F), or at 41°F or less.
3717-1-03.4(F)(1) / Time/temperature controlled for safety food - hot and cold holding.
Critical Repeat Observed foods in the make table upfront not properly keeping the foods cooled. Spinach was 45F, Romaine lettuce 47F and Tomato & Onions 47F etc. Person-in-charge adjusted the temperature in the unit during the last inspection but the internal temperature of the unit has not changed. The unit should be keeping foods below 41F. TCS foods were not being held at the proper temperature..
To prevent the growth of pathogens, except during preparation, cooking, or cooling, or when time is used as a public health control, TCS food shall be held at 135°F or above (except that roasts cooked using time and temperature parameters in 3717-1-03.3 may be held at 130° F), or at 41°F or less.
3717-1-04.4(A)(1) / Equipment - good repair and proper adjustment.
Repeat Observed the seal on the beverage air cooler with a tear. Equipment and/or components are not maintained in good working order.
Equipment shall be maintained in a state of repair and condition that meets the requirements specified under rules 3717-1-04 and 3717-1-04.1 of this code.
[?] Facility Type: Commercial FSO < 25000 sq. ft.
[?] Inspection Type: Follow-up
Inspection Date: 26-July-2016
| The following violation(s) have been corrected since the last inspection. |
|---|
| 3717-1-02.4(C)(10)/Person in charge: duties - ensure employees are properly sanitizing equipment and utensils The person in charge did not ensure that employees are properly sanitizing equipment or utensils because no test kit was available for the dishwasher. To prevent contamination, the person in charge shall ensure that employees are properly sanitizing cleaned multiuse equipment and utensils before they are reused. |
| 3717-1-07(B)/Poisonous or toxic materials: Working containers - common name. Observed a unlabled chemical bottle. To prevent health hazards, working containers used for poisonous or toxic materials such as cleaners and sanitizers taken from bulk supplies shall be clearly and individually identified with the common name of the material. |
| 3717-1-03.2(M)/Wiping cloths - use limitation. Observed a wet wiping cloth being stored in the storage cabinet in the dinning room. Wet wiping cloths should be stored in a sanitizer solution. (1) Cloths that are in use for wiping food spills from tableware and carry-out container that occur as food is being served shall be maintained dry and used for no other purpose; (2) Cloths that are in use for wiping counters and other equipment surfaces shall be: (a) held between uses in a chemical sanitizer of the appropriate concentration; and (b) shall be laundered daily; (3) Cloths that are used with raw animal foods shall be kept separate from cloths used for other purposes; (4) Dry wiping cloths and the chemical sanitizing solution in which wet wiping cloths are held between uses shall be free of food debris and visible soil; (5) Containers of chemical sanitizing solutions specified in paragraph (M)(2)(a) of this rule in which wet wiping cloths are held between uses shall be stored off the floor and used in a manner that prevents contamination of food, equipment, utensils, linens, single-service articles, or single-use articles; (6) Single-use disposable sanitizer wipes shall be used in accordance with EPA-approved manufacturer's label use instructions. |
| 3717-1-06.4(D)/Cleaning ventilation systems, nuisance and discharge prohibition. Observed several vents in the dinning room and kitchen with visible build-up. Intake and exhaust air ducts shall be cleaned and filters changed so they are not a source of contamination. If vented to the outside, ventilation systems may not create a public health hazard or nuisance or unlawful discharge. |
| 3717-1-03.4(F)(1)/Time/temperature controlled for safety food - hot and cold holding. Observed pasta salad being cold held use two pans with ice in the middle at 58F. Person-in-charge put the pasta salad directly into ice to keep the product under 41F. TCS foods were not being held at the proper temperature. To prevent the growth of pathogens, except during preparation, cooking, or cooling, or when time is used as a public health control, TCS food shall be held at 135°F or above (except that roasts cooked using time and temperature parameters in 3717-1-03.3 may be held at 130° F), or at 41°F or less. |
| 3717-1-03.4(G)/Ready-to-eat, time/temperature controlled for safety food - date marking. Observed several products in the pizza make table without a date of expiration. To prevent foodborne illness, refrigerated, ready-to-eat, TCS food held at a temperature of 41°F or less for more than 24 hours shall be clearly marked at the time of preparation or the time the original container is opened to indicate the date or day, that is a maximum of seven days, by which the food shall be consumed, sold, or discarded. The day the food is prepared or opened is day one. |
| 3717-1-04.2(I)/Sanitizing solutions - testing devices. The firm uses a chlorine sanitizer in the dishwasher but only had quat sanitizer strip that are used from the sanitizer from the 3 bay sink. To ensure proper sanitization, a test kit or other device that accurately measures the concentration in PPM (mg/L) of sanitizing solutions shall be provided. |
| 3717-1-04.4(Q)/Utensils, temperature and pressure measuring devices - good repair and calibration. Thermometers being used to measure the temperature of the ingredients on the make table were off calibration. Person-in-charge was shown how to calibrate. (1) Utensils shall be maintained in a state of good repair or shall be discarded; (2) Food temperature measuring devices shall be calibrated as necessary to esnure their accuracy; (3) Ambient air temperature, water pressure, and water temperature measuring devices shall be maintained in good repair and be accurate within the intended range of use. |
| 3717-1-04.8(E)/Equipment, utensils, linens, single-service articles, and single-use articles - storage. Observed clean dishes not properly inverted to help prevent contamination.. Cleaned equipment and utensils, laundered linens, single-service articles, and single-use articles shall be properly stored as described in this rule. |